Abdelkader OUENNOURI

En résumé

Entreprises

• SPIE OGS - Senior Control Room operator and Trainer-coach & Assessor

  Cergy-Pontoise 2013 - maintenant ▪Participation in Commissioning and Start up preparation.
  ▪Key participation in commissioning at start up as CRO(Commissioning and Start-up of Crude oil storage tanks , export pumps, separator ,Flare K.O.Drum, crude oil tanks, water treatment unite and LACT unite using ALDERLY DCS ) .
  ▪Start up, Operate, Monitor and Shut Down Process and Utility Systems.
  ▪Monitor, maintain and optimize process parameters (Level, flow, temperature, pressure ..etc.) within operating requirements.
  ▪Troubleshoot to maximize sales quality and delivery volume to identify problems.
  ▪Monitor and operate control panels, safety and emergency shutdown devices, Fire and Gas Systems.
  ▪Actively and responsibly involved in the Training of other Panel Operator Trainees.
  ▪Provides technical support for the shift supervisors and coverage as required.
  ▪Optimization of plant equipment performance and plant volume performance as prescribed by CARACAL ENERGY production strategy and objectives.
  ▪Ensures/Accepts thorough handover before shift starts and after shift ends.
  ▪Liaison with Plant Foreman, Field Foreman, and Shift Supervisor to ensure that Facility Checks and Specific Tasks are done as required by plant and field conditions.
  ▪Monitoring the status of instruments and recording readings from instruments as required. Working knowledge of plant mass balance data and steady state operations.
  ▪Monitor fault register and status registers of all plant and equipment out of service or under maintenance.
  ▪Monitor inhibits and overrides on the control systems as needed to allow maintenance to be undertaken.
  ▪Handle various emergencies like power failure, Instrument air failure, and critical pump failure.
  ▪Carry out all operations in safe and environmentally
  ▪Report all discharges, leaks, spills, injuries, and incidents, immediately.
  ▪Participates in all Company HSE programs, including PTW, & LOTO.

• SPIE OGS - Senior Control Room operator & Trainer

  Cergy-Pontoise 2013 - maintenant Spie oil & gas, Moundou (Chad)
  Process:
  * Participation in Commissioning and Start up preparation. ;
  * Key participation in commissioning at start up as CRO(Commissioning and Start-up of Crude oil storage tanks , export pumps, separator ,Flare K.O.Drum, crude oil tanks, water treatment unite and LACT unite using ALDERLY DCS ) . ;
  * Start up, Operate, Monitor and Shut Down Process and Utility Systems. ;
  * Monitor, maintain and optimize process parameters (Level, flow, temperature, pressure ..etc.) within operating requirements. ;
  * Troubleshoot to maximize sales quality and delivery volume to identify problems. ;
  * Monitor and operate control panels, safety and emergency shutdown devices, Fire and Gas Systems. ;
  * Ensure accurate production reporting is submitted daily or as required by company and client. ;
  * Actively and responsibly involved in the Training of other Panel Operator Trainees. ;
  * Provides technical support for the shift supervisors and coverage as required. ;
  * Optimization of plant equipment performance and plant volume performance as prescribed by CARACAL ENERGY production strategy and objectives. ;
  * Ensures/Accepts thorough handover before shift starts and after shift ends. ;
  * Liaison with Plant Foreman, Field Foreman, and Shift Supervisor to ensure that Facility Checks and Specific Tasks are done as required by plant and field conditions. ;
  * Ensure accuracy of Plant Daily Report ;
  * Monitoring the status of instruments and recording readings from instruments as required. Working knowledge of plant mass balance data and steady state operations. ;
  * Monitor fault register and status registers of all plant and equipment out of service or under maintenance. ;
  * Monitor inhibits and overrides on the control systems as needed to allow maintenance to be undertaken. ;
  * Handle various emergencies like power failure, Instrument air failure, and critical pump failure.
  Safety:
  * Implementing and enforcing policies and procedures in particular Isolation Standards, and PTW. ;
  * Applying SIPD HSSE Policy in all disciplines and activities ;
  * Carry out all operations in safe and environmentally sound manner. ;
  * Report all discharges, leaks, spills, injuries, and incidents, immediately. ;
  * Ensure personnel understand and comply with current environmental regulations ;
  * Carry out Emergency Response role ;
  * Participates in all Company HSE programs, including PTW, & LOTO. ;
  * Key participant in emergency response
  Maintenance:
  * Assist maintenance operations by applying/removing isolations as required. ;
  * PTW system Authorizer. ;
  * Advise maintenance personnel on hazards of plant and equipment. ;
  * Maintain clear and precise communications during maintenance operations. ;

• ExxonMobil - LNG Mega-Trains Senior Operator

  Notre-Dame de Gravenchon 2012 - 2013 ▪ Check all safety Devices, test/flush safety shower, SCBA and escape set.
  ▪ Routine checked area (checked any leak, piping, tubing, pump condition, compressor, and safety equipment) .
  ▪ Prepare isolation List (positive isolation and DBB).
  ▪ Carry out all different gas and hydrocarbon sample and reading.
  ▪ open, close, and follow PTW (hot and cold).
  ▪ start-up different equipment: Pump, Heater, turbo compressor, gas turbine nuovo pignone FRAME9, Expander.
  ▪ Provide CCR Coverage as required.
  

• EXXONMOBIL - LNG Mega-Trains Senior Operator

  Notre-Dame de Gravenchon 2012 - 2013 * Check all safety Devices, test/flush safety shower, SCBA and escape set. ;
  * Routine checked area (checked any leak, piping, tubing, pump condition, compressor, and safety equipment) . ;
  * Prepare isolation List (positive isolation and DBB). ;
  * Carry out all different gas and hydrocarbon sample and reading. ;
  * open, close, and follow PTW (hot and cold). ;
  * start-up different equipment: Pump, Heater, turbo compressor, gas turbine nuovo pignone FRAME9, Expander. ;
  * Provide CCR Coverage as required. ;

• Hess Corporation - Senior control room operator and Trainer-coach & Assessor

  Paris 2007 - 2013 Use DCS (Delta V- Emerson system) for process control.
  Controlling of operational parameters to obtain optimum yield and on grade products
  Achieve production targets, handling of various troubleshooting and provide solution to the problems.
  Handle various emergencies like power failure, cooling water failure, Instrument air failure, and critical pump failure and compression gas failure.
  Currently, I am with Commissioning start up team
  Commissioning and start up of 2 boosters .3 miscible flood booster compressors (Nuevo Pignone)
  Commissioning and start up Crude oil storage tanks and export pumps.
  Utility system including air compressor (Atlas Copco GA 30/GA37/ZT160), nitrogen production unit, fuel gas and seal gas conditioning.
  
  RVP unit including heater, heat exchanger.
  Water treatment unit (deaerator and chemical injection).

• AMERADA HESS - Operator & Trainer

  2007 - 2012 Senior control room SONAHESS(Sonatrach / AMERADA HESS), Hassi-Messaoued (
  * Perform or assist in the start-up or shutdown of assigned plant and facilities according to approved operating procedures and general instructions. ;
  * Monitor operating conditions and make in-process adjustments either at the control board or within the plant to ensure safe and efficient process operation. ;
  * Maintain log books and operating log sheets recording temperature, pressures, flow rate, volumes received and shipped. ;
  * Monitor indicators to ensure that machines are operating properly. ;
  * Respond to emergency situations by taking necessary shutdown or process adjustment actions to restore normal operating conditions. Make regular inspection of plant facilities to ensure the plant correct functioning. ;
  * Correct malfunctions if appropriate or refer situation to the Shift Supervisor. ;
  * Cooperate with maintenance personnel by identifying/locating and demonstrating malfunctioning plant and equipment and Inspect maintenance work as assigned. ;
  * Ensure that safe operating practices and procedures are adhered to at all times. ;
  * Ensure the panel alarms and ESD are logged and approved by the Shift Supervisor. ;
  * Perform other related duties as assigned by the Area Shift Supervisor. ;
  * Use DCS (Delta V- Emerson system) for process control. ;
  * Controlling of operational parameters to obtain optimum yield and on grade products . ;
  * Achieve production targets, handling of various troubleshooting and provide solution to the problems. ;
  * Handle various emergencies like power failure, cooling water failure, Instrument air failure, and critical pump failure and compression gas failure. ;
  * Involved with Commissioning start up team
  Commissioning and start up of 2 boosters .3 miscible flood booster compressors (Nuevo Pignone) Commissioning and start up Crude oil storage tanks and export pumps.
  * Utility system including air compressor (Atlas Copco GA 30/GA37/ZT160), nitrogen production unit and seal gas conditioning. ;
  * RVP unit including: heater, heat exchanger and storage tank. ;
  * Water treatment unit: deaerator and chemical injection. ;

• Hess Corporation - OIL & GAS Senior Operator

  Paris 2006 - 2007 Control all the equipment and start shut down export pump.
  Maintain Crude oil characteristics including (RVP, BSW and salt content) in coordination with laboratory.
  Control separators 1er stage and second stage (Petrofac separators), test wells for computing their daily production.
  Follow permit to work system (hot & cold) and get all maintenance work done. Ensure the safe running of plants and plant facilities, and report all type of accidents / incident or any near miss incidents.
  Use Allen Bradley UCP control system for rotating machines (Nuevo pignone compressors).

• SONAHESS - OIL & GAS Senior Operator

  2006 - 2006 * Control all the equipment and start shut down export pump, RVP unite(Heater and heat exchanger) . ;
  * Natural gas dehydration system. ;
  * Maintain Crude oil characteristics including (RVP, BSW and salt content) in coordination with laboratory. ;
  * Control separators 1er stage and second stage (Petrofac Separators), test wells for computing their daily production. ;
  * Follow permit to work system (hot & cold) and get all maintenance work done. Ensure the safe running of plants and plant facilities, and report all type of accidents / incident or any near miss incidents. ;
  * Use Allen Bradley UCP control system for rotating machines (Nuevo pignone compressors ;

• SONAHESS - OIL & GAS OPERATOR

  2003 - 2005 * Control all the equipment and start up/ shut down oil export pumps. ;
  * Make up the lube oil for the pumps.
  * Take reading and filling log sheets. ;
  * Walk down around the plant and control of process parameters ;
  * Gauge storage tank ;

• Hess Corporation - OIL & GAS OPERATOR

  Paris 2003 - 2006 Control all the equipment and start up/ shut down oil export pumps.
  Make up the lube oil for the pumps.
  Take reading and filling log sheets.
  Walk down around the plant and control of process parameters.
  Gauge storage tank

Formations

• EMERSON Training Center (Lyon)

  Lyon 2007 - 2007

• Applied University (Skikda)

  Skikda 1999 - 2004 Diploma
  
  Applied University
  Applied Diploma of University instrumentation
  industrial maintenance option: oil and gas instrumentation:
  
  sensors, transmitters, controllers, valves, signal processing, analog and digital, PID et PFD diagram, control system of the turbine SPEEDTRONIC, setting corrective and excessive wo

• IAP (Institut Algerien du Petrole) (Skikda)

  Skikda 1999 - 2004 Applied University Diploma Research Instrumentation oil and gas
  
  Applied Diploma of University instrumentation
  
  industrial maintenance option: oil and gas instrumentation:
  
  sensors, transmitters, controllers, valves, signal processing, analog and digital, PID et PFD diagram, control system of the turbine SPEEDTRONIC, setting corrective and excessive work
  

• LARBI TBESSI High School (Skikda)

  Skikda 1996 - 1999 Bachelor of State Natural
  
  * Bachelor of State Natural Science and Life.

Réseau

• Abdelhak KHALLA

• Abdelmonaim SAHRAOUI

• Ahmed BENISMAIL

• Alexandre FAUST

• Ben Aissaa ABDERRAZAK

• Borhaneddine NASRI

• Djafri NACER

• Herve GIRARD

• Raouf MECHTAR

• Vincent ROUBINET